- Shut off your car
- Find the lever to release the fuel door. It should be located on the floorboard adjacent to the driver’s seat, next to the seat adjustments.
- To open the gasoline tank door, raise the lever.
In This Article...
Why won’t my gas door open?
As was already said, rust and debris accumulation are frequent causes of your gas tank plastic flap not opening or closing properly. Rust, corrosion buildup caused by rust, and a damaged or severely bent flap are further causes of this.
Rust Build-Up
Rust accumulation on the metal gas tank flap’s hinge or latch is one of the most frequent reasons why it won’t open. To fix this problem, disassemble the seal with a flathead screwdriver and remove the rust with a rag. While you’re about it, spray WD40 on both parts to prevent future corrosion or rust growth!
Broken Metal Flap Spring
Another common cause of your metal gas tank flap not opening or closing is a broken metal flap spring. If necessary, disassemble the seal with a flathead screwdriver to access the spring and replace it to solve the problem.
Corrosion Build-up
There’s a good probability your metal gas tank flap has corroded if you discover that it won’t open or close. The best course of action in this situation is to disassemble the seal using a flathead screwdriver and examine it for rust or corrosion. After removing the rust using a rag, WD40 should be applied on the item.
Broken Latch
Last but not least, a damaged gas tank flap latch can prevent the metal gas tank flap from opening or closing. Bend the latch back into its original position if the plastic is still intact and not broken. However, you will need to repair this component if it has rust or is damaged.
Damaged Release Cable
Your metal gas tank flap may also be unable to open or close if the release cable is seriously damaged. If this occurs, you will need to replace the release cable wire in order for your gas cap to open properly.
When the lever on a gas tank breaks, how do you open it?
Registered. By lifting the carpet where the gas door is located and opening the trunk lid, you can still operate the gas door. The cable connecting to the gas door’s latch can then be simply pulled.
Where is the Mitsubishi Outlander’s gas tank latch?
You may open your car’s gas tank cover using a mechanism called the fuel door release lever. Normally utilized in emergency situations, the lever is situated on the left side of the driver’s floorboard.
The gasoline door release lever can be used to unlock the gas tank cover if your automobile breaks down and you need to access the fuel pump.
How do you get the Mitsubishi Eclipse’s gas tank open?
The lever is on the floor immediately next to the driver’s left foot. To open the door to the gas tank, pull up on the lever. The tank’s open door should be visible when you exit the Eclipse on the driver’s side. Enjoy your time outdoors!